Detroit Diesel Engine Series 53 Service Manual

Detroit Diesel Engine Series 53 Service Manual
Detroit Diesel Engine Series 53 Manual Pdf

Detroit Diesel Engine Series 53 This manual covers the basic Series 53 Diesel engines built by the Detroit Diesel Allison Division of General Motors Corporation. Complete instructions on operation, adjustment (tune-up), preventive maintenance and lubrication, and repair (including complete overhaul) are covered. The manual was written primarily for persons servicing and overhauling the engine and, in addition, contains all of the instructions essential to the operators and users. Basic maintenance and overhaul procedures are common to all Series 53 engines and therefore apply to all engine models.

Detroit Diesel Engine Series 53 Service Manual The manual is divided into numbered sections. The first section covers the engine (less major assemblies). The following sections cover a complete system such as the fuel system, lubrication system or air system. Each section is divided into subsections which contain complete maintenance and operating instructions for a specific subassembly on the engine. For example, Section I, which covers the basic engine, contains subsection 1.1 pertaining to the cylinder block, subsection 1.2 covering the cylinder head, etc. The subjects and sections are listed in the Table of Contents on the preceding page. Pages are numbered consecutively, starting with a new Page I at the beginning of each subsection. The illustrations are also numbered consecutively, beginning with a new Figure I at the start of each subsection.

Detroit Diesel Engine Series 53 Parts Information regarding a general subject, such as the lubrication system, can best be located by using the Table of Contents. Opposite each subject in the Table of Contents is a section number which registers with a tab printed on the first page of each section throughout the manual. Information on a specific subassembly or accessory can then be found by consulting the list of contents on the first page of the section. For example, the cylinder liner is part of the basic engine, therefore, it will be found in Section I. Looking down the list of contents on the first page of Section I, the cylinder liner is found to be in subsection 1.6.3.An Alphabetical Index at the back of the manual has been provided as an additional aid for locating information.

0 comments

Leave a Reply

Your email address will not be published.Required fields are marked *